Manual A/C Torque Specifications
WARNING: This page does not describe the selected car, but rather 6 other vehicles, including the 2004 Oldsmobile Bravada, 2004 GMC Envoy XUV, 2004 GMC Envoy XL, 2004 GMC Envoy, and 2004 Chevrolet TrailBlazer. However, it is still accessible from the selected car via links, so may be relevant.
MANUAL A/C TORQUE SPECIFICATIONS
| Application | Ft. Lbs (N.m) |
|---|---|
| A/C Compressor Mounting Bolt | 37 (50) |
| A/C Compressor Rear Bracket Bolt | 18 (25) |
| Accumulator to Evaporator Fitting | 21 (28) |
| Compressor Discharge Hose to Condenser Fitting | 21 (28) |
| Compressor Suction/Discharge Hose to Compressor Bolt | 24 (33) |
| Compressor Suction Hose to Accumulator Fitting | 35 (48) |
| Evaporator Tube to Condenser Fitting | 21 (28) |
| Heater Inlet and Outlet Hoses Bracket Bolt | 18 (25) |
| Heater Inlet Hose Fitting at Intake Manifold | 17 (24) |
| Heater Outlet Hose Bracket Bolt | 18 (25) |
| INCH Lbs. (N.m) | |
| A/C Compressor Cycling Switch | 44 (5) |
| A/C Evaporator and Blower Module Shield Screws | 19 (2.2) |
| A/C Refrigerant Pressure Sensor | 42 (5) |
| Accumulator Clamp Screw | 88 (10) |
| Actuator Retaining Screw (All) | 17 (2) |
| Air Distributor Duct Mounting Screw | 17 (2) |
| Air Inlet Assembly Mounting Stud | 40 (5) |
| Air Outlet Assembly Retaining Screw | 22 (3) |
| Air Temperature Actuator Retaining Screw | 17 (2) |
| Blower Assembly Mounting Nut (RPO C42) | 40 (6) |
| Blower Assembly Mounting Screw (RPO C42) | 40 (6) |
| Blower Assembly Mounting Stud (RPO C42) | 40 (6) |
| Blower Motor Access Cover Screw (RPO C60 and C68) | 22 (3) |
| Blower Motor and Fan Assembly Mounting Screw | 17 (2) |
| Blower Motor Relay Bracket Mounting Screw | 17 (2) |
| Blower Motor Resistor Mounting Screw | 17 (2) |
| Body Harness Connector Support Bracket Mounting Nuts | 80 (9) |
| Compressor Pressure Relief Valve | 80 (9) |
| Condenser Insulator Retaining Screw | 17 (2) |
| Evaporator Case Section to Blower Case Section Retaining Screw | 17 (2) |
| Evaporator Tube Clip Screw | 17 (2) |
| Floor Air Outlet Mounting Screw | 17 (2) |
| HVAC Control Module Screw | 17 (2) |
| Heater Core Access Cover Screw | 17 (2) |
| Heater/Vent Module Mounting Nut | 40 (6) |
| Heater/Vent Module Mounting Screw | 40 (6) |
| Heater/Vent Module Mounting Stud | 40 (6) |
| Intermediate Bracket Bolts | 88 (10) |
| Knee Bolster Bracket Nuts | 49 (6) |