LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2002 >> Blazer 4D Utility, 4WD, Part Time >> Repair and Diagnosis >> External Pages >> Different car >> Section 431 (Engine Mechanical - 6.5L (On-Vehicle)) >> Removal & Installation >> Thermostat >> Removal

Removal & Installation: Thermostat: Removal

WARNING: This page does not describe the selected car, but rather 6 other vehicles, including the 2002 GMC Savana Special, 2002 GMC Savana Camper Special, 2002 GMC Savana, 2002 Chevrolet RV Cutaway, and 2002 Chevrolet Cutaway. However, it is still accessible from the selected car via links, so may be relevant.
NOTE: Thermostats MUST be replaced in pairs.
  1. Remove the air cleaner and the duct assembly. Partially drain the coolant. See DRAINING & FILLING COOLING SYSTEM  under ADJUSTMENTS & INSPECTIONS. Remove the surge tank.
  2. Disconnect the radiator hose from the thermostat housing. Remove the bolts attaching the thermostat housing to the thermostat. Remove the thermostat housing. Remove the thermostats. See Fig 1. Clean the gasket mating surfaces.
Fig 1: Identifying Thermostats And Components
G00307792Courtesy of GENERAL MOTORS CORP.
scientia non olet · About LEMON Manuals