Test Q: Too Cold In Vehicle - Cargo Van With Auxiliary Rear Heater
WARNING: This page is about a different car, the 2002 GMC Savana Special, 2002 GMC Savana Camper Special, 2002 GMC Savana, and 2002 Chevrolet Chevy Express. However, it is still accessible from the selected car via links, so may be relevant.
NOTE:
For circuit reference, see CONNECTOR IDENTIFICATION and/or WIRING DIAGRAMS
.
NOTE:
Definition: The air temperature can not be adjusted from one or both auxiliary controls or auxiliary cooling is insufficient.
- If review of system operation has been performed, go to next step. If review of system operation has not been performed, see DESCRIPTION and OPERATION . Review HVAC operation and perform visual inspection of system. See OPERATION . If system inspection and review of operation has been performed, go to next step.
- Turn ignition on. Place mode switch in any position except off. Place blower switch in each speed position. If blower motor operates in any speed position, go to next step. If blower motor does not operate in any speed position, go to TEST E: BLOWER MOTOR INOPERATIVE .
- If blower motor operates correctly for each speed position, go to next step. If blower motor does not operate correctly for each speed position, go to TEST F: BLOWER MOTOR MALFUNCTION .
- Check cooling system for low coolant level, loose or worn accessory drive belt, leaking radiator or heater hoses, kinked radiator or heater hose, missing radiator cap pressure seal, and a leaking radiator cap. If any of these conditions were found, repair as necessary and go to next step. If none of these conditions were found, go to TEST O: TOO COLD IN VEHICLE .
- Operate system to verify repair. If the condition was corrected, system is okay. If the condition was not corrected, return to step 2.