LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2002 >> Blazer 4D Utility, 4WD, Part Time >> Repair and Diagnosis >> External Pages >> Different car >> Section 1839 (Engine Exhaust System) >> Diagnostic Information and Procedures >> Exhaust Noise

Exhaust Noise

WARNING: This page is about a different car, the 2007 Saturn Vue. However, it is still accessible from the selected car via links, so may be relevant.
Exhaust Noise

Condition Action
CAUTION: While engine is operating, the exhaust system will become extremely hot. To prevent burns avoid contacting a hot exhaust system.
IMPORTANT: Refer to Symptoms - Engine Exhaust  prior to beginning this table.
DEFINITION: An audible or physical noise due to a faulty component or damaged components causing a loose or misaligned exhaust system resulting in a rattle or vibration noises such as: buzz, groan, or hum.
Popping or hissing noise Exhaust leak
Refer to Exhaust Leakage .
Loud exhaust
  1. Compare to a known good vehicle.
  2. Inspect for a damaged or failed muffler or resonator.
  3. Replace the faulty muffler or resonator. Refer to Muffler Replacement (Production Assembly)  or Muffler Replacement (Service Part) .
External rattle or vibration noise
  1. Inspect for a bent or loose hanger, loose heat shield, or loose clamp.
  2. Inspect for a exhaust pipe causing interference.
  3. Repair or replace the affected component. Refer to the affected component's service procedure.
Internal rattle
  1. Test the components by tapping with a rubber mallet to confirm a rattle.
  2. Replace the faulty catalytic converter, resonator, or muffler. Refer to one of the following procedures:
scientia non olet · About LEMON Manuals