LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2002 >> Blazer 4D Utility, 4WD, Part Time >> Repair and Diagnosis >> External Pages >> Different car >> Section 1744 (Roof) >> Repair Instructions >> Luggage Carrier Replacement >> Installation Procedure

Installation Procedure

WARNING: This page is about a different car, the 2003 Saturn Vue. However, it is still accessible from the selected car via links, so may be relevant.
    Fig 1: Installing Remaining Screws To Luggage Carrier
    GM930644Courtesy of GENERAL MOTORS CORP.
  1. Position the front and rear sections of the luggage carrier to the roof.
    2. NOTE: Refer to FASTENER NOTICE in Cautions and Notices.
  2. Install the luggage carrier top screws.

    Tighten:  Tighten the screws to 7 N.m (62 lb in).

    3. Fig 2: Installing Rear Mounting Screws To Luggage Carrier
    GM930635Courtesy of GENERAL MOTORS CORP.
  3. Open the lift gate and support at a 45 degree angle, and install the rear mounting screws to the luggage carrier.

    Tighten:  Tighten the screws to 2.3 N.m (20 lb in).

  4. Remove the roof rear panel applique. Refer to Panel Applique Replacement - Roof Rear in Exterior Trim.
  5. Remove the roof front panel applique. Refer to Panel Applique Replacement - Roof Front in Exterior Trim.
scientia non olet · About LEMON Manuals