LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2002 >> Blazer 4D Utility, 4WD, Part Time >> Repair and Diagnosis >> External Pages >> Different car >> Section 1740 (Mirror System & Window System) >> Diagnostic Information and Procedures >> Defogger Grid Lines Diagnosis

Defogger Grid Lines Diagnosis

WARNING: This page is about a different car, the 2003 Saturn Vue. However, it is still accessible from the selected car via links, so may be relevant.
  1. Start the engine.
  2. Activate the rear window defogger system.
  3. Connect a test lamp to a good ground.
    4. Fig 1: Testing Rear Window Defogger Grid Lines
    GM894100Courtesy of GENERAL MOTORS CORP.
    IMPORTANT: The test lamp brilliance will decrease proportionately to the increased resistance in the grid line as the probe is moved from the battery positive bus wire to the ground bus wire. The test lamp brilliance may vary from one window to another.
  4. Move the test lamp probe from the positive to the negative wire.
    • If the test lamp shows full brilliance at both ends of the grid lines, inspect for an open or poor connection in the ground circuit of the rear window defogger grid. Refer to Testing for Intermittent Conditions and Poor Connections and Connector Repairs in Wiring Systems.
    • If the test lamp goes out, test the grid line in at least 2 places to eliminate the possibility of bridging the open in the grid line.
  5. Once the open is located, repair the grid line. Refer to Grid Line Repair .
scientia non olet · About LEMON Manuals