LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2002 >> Blazer 4D Utility, 4WD, Part Time >> Repair and Diagnosis >> External Pages >> Different car >> Section 1736 (Door System, Mirror System & Window System) >> Repair Instructions >> Door Adjustment - Rear

Door Adjustment - Rear

WARNING: This page is about a different car, the 2003 Saturn Vue. However, it is still accessible from the selected car via links, so may be relevant.
    CAUTION: In order to prevent SIR deployment, personal injury, or unnecessary SIR system repairs, do not strike the door or the door pillar in the area of the side impact sensor (SIS). Turn OFF the ignition and remove the key when performing service in the area of the SIS.
  1. Remove the door striker. Refer to Door Striker Replacement - Rear Door .
  2. For up, down, forward, or rearward adjustment, loosen the hinge to hinge pillar bolts.
  3. Move the door within the door opening to achieve the best alignment and operation.
    4. NOTE: Refer to FASTENER NOTICE in Cautions and Notices.
  4. Tighten all of the hinge fasteners that were loosened.

    Tighten:  Tighten the hinge fasteners to 25 N.m (18 lb ft).

  5. Install the striker to the approximate proper position.
  6. Adjust the door striker. Refer to Door Striker Adjustment - Rear Door .
  7. Inspect the door weatherstrips for proper fit.
scientia non olet · About LEMON Manuals