LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2002 >> Blazer 4D Utility, 4WD, Part Time >> Repair and Diagnosis >> External Pages >> Different car >> Section 1676 (Engine Mechanical - 3.8L) >> Repair Instructions >> On-Vehicle Repair Instructions >> Timing Chain and Sprockets Replacement >> Removal Procedure

Removal Procedure

WARNING: This page is about a different car, the 2003 Buick Regal. However, it is still accessible from the selected car via links, so may be relevant.
  1. Remove the engine front cover. Refer to ENGINE FRONT COVER REPLACEMENT  .
  2. Align the timing marks on the sprockets so that they are as close as possible.
    Fig 1: Aligning Timing Marks On Sprockets
    G01968519Courtesy of GENERAL MOTORS CORP.
  3. Remove the timing chain dampener bolt.
  4. Remove the timing chain dampener.
    Fig 2: Removing Timing Chain Dampener & Bolt
    G01968520Courtesy of GENERAL MOTORS CORP.
  5. Remove the camshaft sprocket bolt.
    Fig 3: Removing Camshaft Sprocket Bolt
    G01968521Courtesy of GENERAL MOTORS CORP.
  6. Remove the camshaft sprocket and the timing chain.
    IMPORTANT: If the sprocket does not come off easily, a light blow on the lower edge of the sprocket with a plastic mallet should dislodge the sprocket.
  7. Remove the crankshaft sprocket.
    Fig 4: Removing Camshaft Sprocket & Timing Chain
    G01968522Courtesy of GENERAL MOTORS CORP.
  8. Remove the balance shaft drive gear in order to access the camshaft thrust plate.
    Fig 5: Removing Balance Shaft Drive Gear
    G01968523Courtesy of GENERAL MOTORS CORP.
  9. Remove the camshaft thrust plate bolts, if required.
    Fig 6: Removing Camshaft Thrust Plate & Bolts
    G01968524Courtesy of GENERAL MOTORS CORP.
  10. Remove the camshaft thrust plate, if required.
  11. Remove the balance shaft driven gear bolt, if required.
  12. Remove the balance shaft driven gear, if required.
    Fig 7: Removing Balance Shaft Driven Gear
    G01968525Courtesy of GENERAL MOTORS CORP.
  13. Clean and inspect all of the timing components for wear and damage. Refer to TIMING CHAIN AND SPROCKETS CLEANING AND INSPECTION (L36)  or TIMING CHAIN AND SPROCKETS CLEANING AND INSPECTION (L67)  .
  14. If the pistons have been moved in the engine, use the following procedure:
    1. 14.1. Turn the crankshaft so that the number one piston is at top dead center.
    2. 14.2. Turn the camshaft so that, with the sprocket temporarily installed, the timing mark is straight down.