LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2002 >> Blazer 4D Utility, 4WD, Part Time >> Repair and Diagnosis >> External Pages >> Different car >> Section 1599 (Power Sun Roof) >> Repair Instructions >> Sunroof Replacement >> Installation Procedure

Installation Procedure

WARNING: This page is about a different car, the 2002 Oldsmobile Bravada, 2002 GMC Envoy XL, 2002 GMC Envoy, and 2002 Chevrolet TrailBlazer. However, it is still accessible from the selected car via links, so may be relevant.
  1. Install the sunshade to the sunroof assembly. Refer to Sunroof Sunshade Panel Replacement .
  2. Install the glass panel to the sunroof assembly. Refer to Sunroof Glass Panel Replacement .
  3. Install the sunroof module to the sunroof assembly. Refer to Power Sunroof Module Replacement .
  4. Install the drive motor to the sunroof assembly. Refer to Power Sunroof Motor Replacement .
    5. Fig 1: Identifying Sunroof Module Assembly
    GM749611Courtesy of GENERAL MOTORS CORP.
  5. Position the sunroof assembly to the vehicle with an assistant.
    6. NOTE: Refer to Fastener Notice in Cautions and Notices.
  6. Install the bolts that retain the sunroof assembly to the roof panel.

    Tighten:  Tighten the bolts to 10 N.m (7 lb ft).

  7. Connect the drain hoses to the sunroof assembly. Refer to the following procedures:
    8. Fig 2: Accessing Sunroof Assembly Electrical Connector
    GM749612Courtesy of GENERAL MOTORS CORP.
  8. Connect the sunroof harness electrical connector.
  9. Install the headliner. Refer to Headliner Replacement (Trailblazer EXT, Envoy XL) or Headliner Replacement (Trailblazer, Envoy, Bravada) in Interior Trim.
scientia non olet · About LEMON Manuals