Diagnostic Aids

WARNING: This page is about a different car, the 2003 Oldsmobile Bravada, 2003 GMC Envoy XL, 2003 GMC Envoy, and 2003 Chevrolet TrailBlazer. However, it is still accessible from the selected car via links, so may be relevant.

Turning off the engine when the cooling fan clutch is engaged, the cooling fan clutch will be engaged at engine restart. This may cause an excessive noise concern. This is a normal condition.
If the engine is turned off for an extended period of time, usually over night, the hydraulic fluid may fill working chamber and cause limited slip at engine restart. This may cause the excessive noise condition. This is a normal condition.
To engage the cooling fan clutch, it can take up to 2 minutes for a 100% command with the engine at 2000 RPM. The lower the engine speed, the longer it will take the cooling fan clutch to engage.
To disengage the cooling fan clutch, it can take up to 2 minutes with the engine at 2000 RPM. The lower the engine speed, the longer it will take to disengage.
In lower ambient air temperatures the cooling fan clutch will engage in less time, however it will take longer to disengage.
An inline connector could cause an intermittent DTC. Ensure to test for poor connections and pin retention at all inline connectors. Refer to system schematics for connector and locations.
If the condition is not present, refer to TESTING FOR INTERMITTENT AND POOR CONNECTIONS in Wiring Systems.