LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2002 >> Blazer 4D Utility, 4WD, Part Time >> Repair and Diagnosis >> External Pages >> Different car >> Section 1437 (Exterior Trim) >> Repair Instructions >> Grille Replacement (Envoy, Envoy XUV) >> Removal Procedure

Removal Procedure

WARNING: This page does not describe the selected car, but rather 6 other vehicles, including the 2004 Oldsmobile Bravada, 2004 GMC Envoy XUV, 2004 GMC Envoy XL, 2004 GMC Envoy, and 2004 Chevrolet TrailBlazer. However, it is still accessible from the selected car via links, so may be relevant.
  1. Use a flat-bladed tool in order to release the clips that retain the top of the grille (2) to the headlamp housing panel.
  2. Lift the grille (2) out of position.
  3. Release the quick-connect (4) on the headlamp washer supply hose.
  4. Remove the grille from the vehicle.
    Fig 1: Removing Grille (Envoy, Envoy XUV)
    GM740799Courtesy of GENERAL MOTORS CORP.
  5. Place the grille on a clean, prepared surface.
    6. Fig 2: Removing Washer Nozzles From Grille (Envoy, Envoy XUV)
    GM740800Courtesy of GENERAL MOTORS CORP.
  6. Release the quick-connects (3) on the headlamp washer nozzle hoses.
  7. Spread the retaining tabs (1) on the grille in order to release the headlamp washer nozzle.
  8. Remove the headlamp washer nozzle from the front of the grille.
  9. Remove the headlamp washer hose (4) from the grille.
scientia non olet · About LEMON Manuals