LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2002 >> Blazer 4D Utility, 4WD, Part Time >> Repair and Diagnosis >> External Pages >> Different car >> Section 1433 (Sunroof System) >> Repair Instructions >> Luggage Carrier Replacement >> Installation Procedure

Installation Procedure

WARNING: This page does not describe the selected car, but rather 6 other vehicles, including the 2004 Oldsmobile Bravada, 2004 GMC Envoy XUV, 2004 GMC Envoy XL, 2004 GMC Envoy, and 2004 Chevrolet TrailBlazer. However, it is still accessible from the selected car via links, so may be relevant.
    Fig 1: Removing/Installing Luggage Carrier
    GM676813Courtesy of GENERAL MOTORS CORP.
  1. Position the side rails (2) to the roof panel.
    2. NOTE: Refer to Fastener Notice in Cautions and Notices.
  2. Install the bolts which retain the side rails to the roof panel, starting with the rearmost bolt first on each side.

    Tighten:  Tighten the luggage carrier side rail bolts to 5 N.m (44 lb in).

    3. IMPORTANT: Ensure that the loops on the cross rails are indexed toward the front of the vehicle.
  3. Install the cross rails (4) to the side rails.
  4. Lock the cross rails to the slide rails.
  5. Install and secure the finish covers (3) to the side rails.
scientia non olet · About LEMON Manuals