LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2002 >> Blazer 4D Utility, 4WD, Part Time >> Repair and Diagnosis >> External Pages >> Different car >> Section 1336 (Door System, Mirror System & Window System) >> Repair Instructions >> Door Replacement - Side Front >> Removal Procedure

Removal Procedure

WARNING: This page is about a different car, the 2004 Pontiac Vibe. However, it is still accessible from the selected car via links, so may be relevant.
  1. Remove the door trim panel. Refer to Trim Panel Replacement - Side Front Door .
  2. Remove the water deflector. Refer to Water Deflector Replacement - Front Door .
  3. Remove the rear view mirror. Refer to Mirror Replacement - Power .
  4. Remove the outer sealing strip. Refer to Sealing Strip Replacement - Front Door Window Belt Outer .
  5. Remove the door weather-strip. Refer to Weatherstrip Replacement - Front Door .
  6. Remove the door window weather-strip. Refer to Weatherstrip Replacement - Front Door Window .
  7. Remove the window guide. Refer to Window Guide Replacement - Door .
  8. Remove the door lock. Refer to Lock Replacement - Front Door .
  9. Remove the door lock cylinder. Refer to Lock Cylinder Replacement - Door .
  10. Remove the outside door handle. Refer to Door Handle Replacement - Front Outside .
  11. Remove the door window. Refer to Window Replacement - Front Door .
  12. Remove the door window regulator and motor. Refer to Window Regulator Replacement - Front Door .
  13. Remove the front upper door speaker. Refer to Speaker Replacement - Front Upper in Entertainment.
  14. Remove the front lower door speaker. Refer to Speaker Replacement - Front Lower in Entertainment.
  15. Remove the front door body side molding. Refer to Molding Replacement - Front Door Body Side in Exterior Trim.
  16. Remove the front lower door side molding. Refer to Molding Replacement - Front Side Door Lower in Exterior Trim.
  17. Remove the left fender, if necessary. Refer to Fender Replacement - Front - Left in Body Front End.
  18. Remove the right fender, if necessary. Refer to Fender Replacement - Front - Right in Body Front End.
  19. Remove the door check link. Refer to Door Check Link Replacement - Front .
    20. Fig 1: Side Front Door Components
    GM626953Courtesy of GENERAL MOTORS CORP.
  20. Release the door wiring harness grommet and unroute the wiring harness (3) from the door (6) and door jamb, if equipped.
  21. Remove the front door wiring harness from the vehicle, if equipped.
  22. Remove all the retainers from the front door (6).
  23. Mark the door hinge (2, 4) location.
  24. Remove the following components from the vehicle:
    • The 4 door to hinge bolts (1, 5)
    • The front door (6)
scientia non olet · About LEMON Manuals