Torque Specifications: 8.1L
WARNING: This page does not describe the selected car, but rather 6 other vehicles, including the 2002 GMC Savana Special, 2002 GMC Savana Camper Special, 2002 GMC Savana, 2002 Chevrolet RV Cutaway, and 2002 Chevrolet Cutaway. However, it is still accessible from the selected car via links, so may be relevant.
TORQUE SPECIFICATIONS (8.1L)
| Component | Ft. Lbs. (N.m) |
|---|---|
| AIR Pipe-To-Exhaust Manifold Bolt | 18 (25) |
| EGR Pipe-To-EGR Valve Bolt | 22 (30) |
| EGR Valve Bolt | 18 (25) |
| EGR Valve Pipe-To-Cylinder Head Bolt | 37 (50) |
| EGR Valve Pipe-To-Exhaust Manifold Nut | 22 (30) |
| Engine Coolant Temperature (ECT) Sensor | 15 (20) |
| Exhaust Gas Recirculation (EGR) Valve Nut | 22 (30) |
| Fuel Filter Fitting | 22 (30) |
| Fuel Pipe Retaining Clip Nut | 21 (28) |
| Fuel Tank Strap Bolt | 15 (20) |
| Heated Oxygen Sensor (HO2S) | 30 (41) |
| Knock Sensor (KS) | 14 (19) |
| Secondary Air Injection (AIR) Crossover Pipe Bracket Fastener | 37 (50) |
| INCH Lbs. (N.m) | |
| Accelerator Pedal Mounting Bolt | 44 (5) |
| Air Cleaner Assembly Bolt | 159 (18) |
| Camshaft Position (CMP) Sensor Bolt | 89 (10) |
| Crankshaft Position (CKP) Sensor Bolt | 106 (12) |
| Engine Sight Shield Bolt | 89 (10) |
| Engine Sight Shield Bracket Bolt | 89 (10) |
| Evaporative (EVAP) Emission Canister Bracket Mounting Bolt | 106 (12) |
| Evaporative (EVAP) Emission Purge Solenoid Shoulder Bolt | 93 (10.5) |
| Evaporative (EVAP) Emission Purge Valve Retaining Bolt | 89 (10) |
| Fuel Fill Hose Clamp | 24 (2.8) |
| Fuel Fill Pipe Ground Strap Bolt | 80 (9) |
| Fuel Fill Pipe Housing-To-Fill Pipe Bolt | 20 (2.3) |
| Fuel Injection Sight Shield Retaining Bolt | 89 (10) |
| Fuel Pipe Retaining Clip Bolt | 106 (12) |
| Fuel Rail Attaching Bolt | 106 (12) |
| Ignition Coil Attaching Bolt | 106 (12) |
| Manifold Absolute Pressure (MAP) Sensor Retaining Bolt | 106 (12) |
| Mass Air Flow (MAF) Sensor Clamp | 35 (4) |
| Powertrain Control Module (PCM) Connector End Bolt | 71 (8) |
| Secondary Air Injection (AIR) Manifold Pipe Fastener | 106 (12) |
| Secondary Air Injection (AIR) Pump and Bracket Assembly Fastener | 89 (10) |
| Throttle Actuator Control (TAC) Retaining Fastener | 27 (3) |
| Throttle Body Attaching Bolt | 89 (10) |
| Upper Engine Wire Harness Bracket Nut | 89 (10) |