LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2002 >> Blazer 4D Utility, 4WD, Part Time >> Repair and Diagnosis >> External Pages >> Different car >> Section 1210 (Door System, Mirror System & Window System) >> Repair Instructions >> Door Handle Replacement - Outside >> Removal Procedure

Removal Procedure

WARNING: This page is about a different car, the 2003 Chevrolet Corvette. However, it is still accessible from the selected car via links, so may be relevant.
CAUTION: Refer to EXPRESS WINDOW DOWN CAUTION in Cautions and Notices.

Important:  The clip retaining the outside door handle opening rod to the door lock should not be reused. To ensure the proper retention of the rod, the clip must be replaced after being opened to release the rod.

  1. Remove the door trim panel. Refer to TRIM PANEL REPLACEMENT - DOOR .
    Fig 1: Door Trim Panel
    G01451168Courtesy of GENERAL MOTORS CORP.
  2. Remove the water deflector.
    Fig 2: Water Deflector
    G01451169Courtesy of GENERAL MOTORS CORP.
  3. Remove the rear sight/access plugs.
    Fig 3: Rear Sight/Access Plugs
    G01451170Courtesy of GENERAL MOTORS CORP.
  4. Reconnect the power window switch and raise the door window.
  5. Disconnect the switch.
    Fig 4: Removing Power Window Switch & Raise Door Window
    G01451171Courtesy of GENERAL MOTORS CORP.
  6. Remove the lock rod from the outside handle lock cylinder lever (key lockable outside handle).

    Important:  To ensure the proper retention of the door opening rod to the door lock, the lock clip must be replaced after being opened to release the rod.

  7. Remove the clip attaching the outside handle door opening rod to the door lock.
    1. Remove the clip from the door opening rod by prying open the clip using a coolant hose removal tool.
    2. Remove the clip from the door lock by cutting the base of the clip off with a pair of side cutters.
      Fig 5: Removing Lock Rod From Outside Handle Lock Cylinder Lever
      G01451172Courtesy of GENERAL MOTORS CORP.
  8. Remove the bolts attaching the outside handle.
  9. Remove the handle and the gasket.
  10. Transfer parts as necessary.
    Fig 6: Removing Bolts Attaching Outside Handle
    G01451173Courtesy of GENERAL MOTORS CORP.