| Accelerator Pedal Position Sensor Retaining Bolts (4.8L, 5.3L, 6.0L & 8.1L) |
15 (20) |
| Battery Cable-To-Battery Bolt |
11 (15) |
| Distributor Hold-down Bolt (4.3L) |
18 (25) |
| Driveshaft Center Bearing Support Nuts (Cab & Chassis) |
30 (40) |
| Driveshaft-To-Rear Axle Pinion Yoke Bolts (Cab & Chassis) |
18 (25) |
| Driveshaft-To-Transmission/Transfer Case Yoke Bolts (Cab & Chassis With Two-Piece Driveshaft) |
18 (25) |
| EGR Valve Mounting Bolts/Nuts |
| 4.3L, 4.8L, 5.3L & 6.0L |
|
| 8.1L |
16 (22) |
| Engine Coolant Temperature Sensor |
15 (20) |
| Fuel Line Fittings (4.3L) |
21 (28) |
| Fuel Tank Shield-To-Frame Bolts |
| Cab & Chassis; Rear Tank |
13 (18) |
| Except Cab & Chassis; Rear Tank |
|
| Fuel Tank Strap Retaining Bolts |
30 (40) |
| Generator Mounting Bolts |
37 (50) |
| Knock Sensor Retaining Bolt (4.3L) |
18 (25) |
| Knock Sensors |
| 4.8L, 5.3L & 6.0L |
15 (20) |
| 8.1L |
14 (19) |
| Oxygen Sensors |
31 (42) |
| Spark Plugs |
| 4.3L, 4.8L, 5.3L & 6.0L |
|
| 8.1L |
|
| Starter Mounting Bolts (4.8L, 5.3L & 6.0L) |
37 (50) |
| Steering Linkage Shield Bolts |
15 (20) |
| INCH Lbs. (N.m) |
| Accelerator Control Cable Bracket-To-Throttle Body & Intake Manifold Studs/Nuts (4.3L) |
106 (12.0) |
| Accelerator Control Cable Routing Bracket-To-Throttle Body Retaining Nuts (4.3L) |
80 (9.0) |
| Air Cleaner Outlet Duct Adapter Stud (4.3L) |
71 (8.0) |
| Air Cleaner Outlet Duct-To-MAF Sensor Clamp |
35 (4.0) |
| Air Cleaner Resonator-To-Throttle Body Clamp |
35 (4.0) |
| Camshaft Position Sensor Retaining Bolt/Screws |
| 4.3L |
19 (2.2) |
| 4.8L, 5.3L & 6.0L |
|
| 8.1L |
106 (12.0) |
| Crankshaft Position Sensor Retaining Bolt |
| 4.3L |
80 (9.0) |
| 4.8L, 5.3L & 6.0L |
|
| 8.1L |
106 (12.0) |
| Crossover Pipe-To-Right Fuel Rail Retainer Screw (4.8L, 5.3L & 6.0L) |
34 (3.8) |
| Distributor Cap Screws (4.3L) |
21 (2.4) |
| Distributor Rotor Screws (4.3L) |
18 (2.0) |
| Engine Wiring Harness Bracket-To-Intake Manifold Stud Retaining Nuts (4.3L) |
106 (12.0) |
| Engine Wiring Harness Clip Bolt (4.3L) |
80 (9.0) |
| Engine Wiring Harness Ground Wire Nut (4.3L) |
|
| Engine Wiring Harness Rear Bracket Nut (4.3L) |
80 (9.0) |
| EVAP Canister Bracket-To-Crossmember Mounting Bolt (Sierra & Silverado) |
|
| EVAP Canister Purge Solenoid Retaining Bolts/Nuts |
| 4.3L |
106 (12.0) |
| 4.8L, 5.3L, 6.0L |
93 (10.5) |
| 8.1L |
89 (10.0) |
| EVAP Canister-To-Crossmember Retaining Nuts (Cab & Chassis) |
89 (10.0) |
| EVAP Canister Vent Valve Bracket Mounting Bolt |
106 (12.0) |
| Flywheel Cover Bolt (4.8L, 5.3L & 6.0L) |
80 (9.0) |
| Fuel Filler Pipe Ground Strap Retaining Bolt (4.3L, 4.8L, 5.3L & 6.0L) |
80 (9.0) |
| Fuel Filler Pipe Housing-To-Truck Bed Bolts (Sierra & Silverado) |
20 (2.3) |
| Fuel Filler Pipe Housing-To-Filler Pipe Bolts (Sierra & Silverado) |
20 (2.3) |
| Fuel Fill & Vent Pipe Hose Clamps |
22 (2.5) |
| Fuel Line Bracket-To-Bellhousing Stud Nut |
| 4.3L |
|
| 8.1L |
|
| Fuel Line-To-Intake Manifold Bracket Retaining Bolt (4.3L) |
53 (6.0) |
| Fuel Rail Retaining Bolts |
| 4.8L, 5.3L & 6.0L |
89 (10.0) |
| 8.1L |
106 (12.0) |
| Generator Positive Post Cable Nut |
80 (9.0) |
| Idle Air Control Valve Mounting Screws (4.3L, 4.8L, 5.3L & 6.0L) |
27 (3.0) |
| Ignition Coil Bracket-To-Intake Manifold Studs (4.3L) |
97 (11.0) |
| Ignition Coil/Control Module-To-Bracket Retaining Screws (4.3L) |
32 (3.5) |
| Ignition Coil Retaining Bolts |
| 4.8L, 5.3L & 6.0L |
71 (8.0L) |
| 8.1L |
106 (12.0) |
| Injector Retainer Lock Nuts (4.3L) |
27 (3.0) |
| Intake Manifold Sight Shield Bracket/Retainer Bolts/Nuts (4.8L, 5.3L, 6.0L & 8.1L) |
44 (5.0) |
| Intake Manifold Sight Shield Fastener (4.8L, 5.3L, 6.0L & 8.1L) |
89 (10.0) |
| Manifold Absolute Pressure Sensor Retaining Bolt (8.1L) |
106 (12.0) |
| PCM Harness Connector Fasteners |
71 (8.0) |
| Positive Battery Cable-To-Solenoid Nut (4.8L, 5.3L & 6.0L) |
80 (9.0) |
| Starter Solenoid Start Lead Terminal Nut (4.8L, 5.3L & 6.0L) |
30 (3.4) |
| Throttle Body-To-Intake Manifold Studs/Nuts |
| 4.3L |
80 (9.0) |
| 4.8L, 5.3L, 6.0L & 8.1L |
89 (10.0) |
| Throttle Position Sensor Mounting Screws (4.3L, 4.8L, 5.3L & 6.0L) |
18 (2.0) |
| Upper Engine Wiring Harness Retainer Nut (4.8L, 5.3L & 6.0L) |
49 (5.5) |
| Upper Intake Manifold Retaining Studs (4.3L) |
80 (9.0) |