LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2002 >> Blazer 4D Utility, 4WD, Part Time >> Repair and Diagnosis >> External Pages >> Different car >> Section 1175 (Heating, Ventilation And Air Conditioning) >> Repair Instructions >> Evaporator Tube Replacement - Front >> Removal Procedure

Removal Procedure

WARNING: This page is about a different car, the 2003 Chevrolet Corvette. However, it is still accessible from the selected car via links, so may be relevant.
  1. Recover the refrigerant from the A/C system. Refer to REFRIGERANT RECOVERY AND RECHARGING  .
  2. Remove the battery heat shield. Refer to BATTERY HEAT SHIELD REPLACEMENT in Engine Electrical.
  3. Remove the upper radiator support. Refer to RADIATOR SUPPORT REPLACEMENT in Engine Cooling.
  4. Disconnect the electrical connector from the refrigerant pressure sensor.
    Fig 1: Disconnecting Electrical Connector From Refrigerant Pressure Sensor
    G01418548Courtesy of GENERAL MOTORS CORP.
  5. Remove the bolt which secures the front evaporator tube to the condenser.

    Important:  Cap or tape the open A/C components immediately to prevent system contamination.

  6. Disconnect the front evaporator tube from the condenser.
  7. Remove and discard the O-ring.
  8. Cap or tape the open front evaporator tube and the condenser.
    Fig 2: Removing Front Evaporator Tube To Condenser
    G01418549Courtesy of GENERAL MOTORS CORP.
  9. Remove the bolt which secures the front evaporator tube to the rear evaporator tube.
  10. Disconnect the front evaporator tube from the rear evaporator tube.
  11. Remove and discard the O-ring.
  12. Cap or tape the front and rear evaporator tubes.
    Fig 3: Disconnecting Front Evaporator Tube From Rear Evaporator Tube
    G01418550Courtesy of GENERAL MOTORS CORP.
  13. Remove the front evaporator tube from the vehicle.
  14. Remove the A/C refrigerant pressure sensor from the evaporator tube.
  15. Discard the O-ring.
Fig 4: Identifying A/C Refrigerant Pressure Sensor On Evaporator Tube
G01418551Courtesy of GENERAL MOTORS CORP.
scientia non olet · About LEMON Manuals