LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2002 >> Blazer 4D Utility, 4WD, Part Time >> Repair and Diagnosis >> External Pages >> Different car >> Section 1151 (Heating, Ventilation And Air Conditioning) >> Repair Instructions >> Floor Air Door Replacement >> Removal Procedure

Removal Procedure

WARNING: This page is about a different car, the 2004 Pontiac Aztek and 2004 Buick Rendezvous. However, it is still accessible from the selected car via links, so may be relevant.
  1. Remove the heater outlet duct. Refer to Air Outlet Replacement - Floor .
  2. Remove the mode actuator. Refer to Mode Actuator Replacement in HVAC Systems - Manual or Mode Actuator Replacement in HVAC Systems - Automatic.
    3. Fig 1: Locating Mode Door Actuator Mounting Bracket Screws
    GM867772Courtesy of GENERAL MOTORS CORP.
  3. Remove the mode door actuator mounting bracket screws.
  4. Remove the mode door actuator mounting bracket.
    5. Fig 2: Identifying Floor Air Door Lever
    GM867768Courtesy of GENERAL MOTORS CORP.
  5. Disconnect and remove the floor air door lever from the floor air door.
    6. Fig 3: View Of Floor Air Door
    GM867789Courtesy of GENERAL MOTORS CORP.
  6. Remove the floor air door from the HVAC module.
scientia non olet · About LEMON Manuals