LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2002 >> Blazer 4D Utility, 4WD, Part Time >> Repair and Diagnosis >> External Pages >> Different car >> Section 1141 (Sunroof System) >> Repair Instructions >> Luggage Carrier Replacement >> Installation Procedure

Installation Procedure

WARNING: This page is about a different car, the 2004 Pontiac Aztek and 2004 Buick Rendezvous. However, it is still accessible from the selected car via links, so may be relevant.
  1. Position the luggage carrier side rails to the roof.
    2. Fig 1: Identifying Luggage Carrier Side Rail Screws
    GM741621Courtesy of GENERAL MOTORS CORP.
    NOTE: Refer to Fastener Notice in Cautions and Notices.
  2. Install the luggage carrier side rail screws to the luggage carrier.

    Tighten:  Tighten the luggage carrier side rail screws to 6 N.m (53 lb in).

    3. Fig 2: Locating Luggage Carrier Cross Rail Levers
    GM741620Courtesy of GENERAL MOTORS CORP.
  3. Lift up on the luggage carrier cross rail levers in order to engage the cross rails into the side rails.
  4. Slide the luggage carrier cross rails to the desired position.
  5. Release the levers on the luggage carrier cross rails to lock them into position.
    6. Fig 3: Identifying Luggage Carrier Side Rail Trim Covers
    GM761264Courtesy of GENERAL MOTORS CORP.
  6. Install the luggage carrier side rail trim covers to the slots in the rails, pressing into place until fully seated.
scientia non olet · About LEMON Manuals