LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2002 >> Astro Van Passenger, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 825 (Body Rear End) >> Repair Instructions >> Lock Replacement - Rear Door Remote >> Installation Procedure

Installation Procedure

WARNING: This page is about a different car, the 2003 GMC Safari and 2003 Chevrolet Astro. However, it is still accessible from the selected car via links, so may be relevant.
  1. Install the clips to the remote lock.
  2. Install the remote lock.
    NOTE: Refer to FASTENER NOTICE in Cautions and Notices.
  3. Install the remote lock nuts.

    Tighten 

    Tighten the remote lock nuts to 7 N.m (62 lb in).

    Fig 1: Installing Remote Lock - Rear Door
    G01567362Courtesy of GENERAL MOTORS CORP.
  4. Install the control rods through the clips to the remote lock.
  5. Install the water deflector. Refer to WATER DEFLECTOR REPLACEMENT .
  6. Install the trim panel. Refer to TRIM PANEL REPLACEMENT - REAR DOOR (CARGO DOORS)  or TRIM PANEL REPLACEMENT - REAR DOOR (E54)  .
    Fig 2: Installing Remote Lock Control Rods
    G01567363Courtesy of GENERAL MOTORS CORP.
scientia non olet · About LEMON Manuals