LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2002 >> Astro Van Passenger, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 825 (Body Rear End) >> Repair Instructions >> Lock Replacement - Rear Door (E54) >> Installation Procedure

Installation Procedure

WARNING: This page is about a different car, the 2003 GMC Safari and 2003 Chevrolet Astro. However, it is still accessible from the selected car via links, so may be relevant.
  1. Install the clips to the lock.
  2. Install the lock to the door.
    NOTE: Refer to FASTENER NOTICE in Cautions and Notices.
    Fig 1: Installing Door Lock
    G01567383Courtesy of GENERAL MOTORS CORP.
  3. Install the screws that retain the lock to the door.

    Tighten 

    Tighten the screws that retain the lock to the door to 11 N.m (97 lb in).

  4. Install the control rods through the clips to the lock assembly.
  5. Install the water deflector. Refer to WATER DEFLECTOR REPLACEMENT .
  6. Install the trim panel. Refer to TRIM PANEL REPLACEMENT - REAR DOOR (CARGO DOORS)  or TRIM PANEL REPLACEMENT - REAR DOOR (E54)  .
scientia non olet · About LEMON Manuals