LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2002 >> Astro Van Passenger, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 825 (Body Rear End) >> Repair Instructions >> License Plate Pocket Replacement >> Installation Procedure

Installation Procedure

WARNING: This page is about a different car, the 2003 GMC Safari and 2003 Chevrolet Astro. However, it is still accessible from the selected car via links, so may be relevant.
  1. Install the housing (2) to the door.
  2. Install the door handle. Refer to HANDLE REPLACEMENT - REAR DOOR OUTSIDE .
    NOTE: Refer to FASTENER NOTICE in Cautions and Notices.
  3. Install the housing to door bolts (1).

    Tighten 

    Tighten the door bolts to 4 N.m (35 lb in).

  4. Install the lamp harness to the housing.
  5. Install the water deflector. Refer to WATER DEFLECTOR REPLACEMENT .
  6. Install the trim panel. Refer to TRIM PANEL REPLACEMENT - REAR DOOR (CARGO DOORS)  or TRIM PANEL REPLACEMENT - REAR DOOR (E54)  .
    Fig 1: Installing Housing Bolts
    G01567307Courtesy of GENERAL MOTORS CORP.
scientia non olet · About LEMON Manuals