LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2002 >> Astro Van Passenger, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 825 (Body Rear End) >> Repair Instructions >> Latch Replacement - Lower >> Removal Procedure

Removal Procedure

WARNING: This page is about a different car, the 2003 GMC Safari and 2003 Chevrolet Astro. However, it is still accessible from the selected car via links, so may be relevant.
  1. Remove the trim panel. Refer to TRIM PANEL REPLACEMENT - REAR DOOR (CARGO DOORS)  or TRIM PANEL REPLACEMENT - REAR DOOR (E54)  .
  2. Separate the weatherstrip deflector at the perforation. Use a sharp-bladed tool if needed. Refer to WATER DEFLECTOR REPLACEMENT .
  3. Remove the control rod from the lock assembly.
    Fig 1: Removing Lock Assembly Control Rod
    G01567364Courtesy of GENERAL MOTORS CORP.
  4. Remove the bolts and the reinforcement.
    Fig 2: Removing Bolts And Reinforcement
    G01567365Courtesy of GENERAL MOTORS CORP.
  5. Remove the following components from the door:
    • The latch
    • The rod
    • The retainer
  6. Remove the rod and the retainer from the latch.
    Fig 3: Removing Latch Rod And Retainer
    G01567366Courtesy of GENERAL MOTORS CORP.
scientia non olet · About LEMON Manuals