LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2002 >> Astro Van Passenger, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 825 (Body Rear End) >> Repair Instructions >> Latch Replacement - Lower >> Installation Procedure

Installation Procedure

WARNING: This page is about a different car, the 2003 GMC Safari and 2003 Chevrolet Astro. However, it is still accessible from the selected car via links, so may be relevant.
  1. Install the control rod and the retainer to the latch.
  2. Install the retainer as shown in order to prevent squeaks and rattles.
    Fig 1: Installing Latch Control Rod And Retainer
    G01567367Courtesy of GENERAL MOTORS CORP.
    NOTE: Refer to FASTENER NOTICE in Cautions and Notices.
  3. Install the following components to the door. Ensure that the arrow on the retainer points toward the front of the vehicle:
    • The latch
    • The retainer
    • The bolts

    Tighten 

    Tighten the bolts to the door to 8 N.m (71 lb in).

    Fig 2: Installing Bolts And Reinforcement
    G01567368Courtesy of GENERAL MOTORS CORP.

    Important:  Install new nylon retainers whenever you remove the control rods.

  4. Install the control rod to the lock assembly.
  5. Install the water deflector. Refer to WATER DEFLECTOR REPLACEMENT .
  6. Install the trim panel. Refer to TRIM PANEL REPLACEMENT - REAR DOOR (CARGO DOORS)  or TRIM PANEL REPLACEMENT - REAR DOOR (E54)  .
    Fig 3: Install Lock Assembly Control Rod
    G01567369Courtesy of GENERAL MOTORS CORP.
scientia non olet · About LEMON Manuals