LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2002 >> Astro Van Passenger, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 825 (Body Rear End) >> Repair Instructions >> Handle Replacement - Rear Door Outside >> Installation Procedure

Installation Procedure

WARNING: This page is about a different car, the 2003 GMC Safari and 2003 Chevrolet Astro. However, it is still accessible from the selected car via links, so may be relevant.
  1. Install the outside handle to the door.
    NOTE: Refer to FASTENER NOTICE in Cautions and Notices.
  2. Install the outside handle nuts.

    Tighten 

    Tighten the outside handle nuts to 7 N.m (62 lb in).

  3. Install the control rod to the outside handle through the clip.
  4. Install the water deflector. Refer to WATER DEFLECTOR REPLACEMENT .
  5. Install the trim panel. Refer to TRIM PANEL REPLACEMENT - REAR DOOR (CARGO DOORS)  or TRIM PANEL REPLACEMENT - REAR DOOR (E54)  .
    Fig 1: Installing Rear Door Outside Handle
    G01567347Courtesy of GENERAL MOTORS CORP.
scientia non olet · About LEMON Manuals