LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2002 >> Astro Van Passenger, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 825 (Body Rear End) >> Repair Instructions >> Handle Replacement - Rear Door Inside >> Installation Procedure

Installation Procedure

WARNING: This page is about a different car, the 2003 GMC Safari and 2003 Chevrolet Astro. However, it is still accessible from the selected car via links, so may be relevant.
  1. Install the door handle to the door.
    Fig 1: Installing Door Handle
    G01567356Courtesy of GENERAL MOTORS CORP.
    NOTE: Refer to FASTENER NOTICE in Cautions and Notices.
  2. Install the door handle nuts (2).

    Tighten 

    Tighten the nuts to 11 N.m (97 lb in).

    Important:  Install new control rod retainers whenever they are removed.

  3. Install the control rod to the door handle (1).
  4. Install the water deflector. Refer to WATER DEFLECTOR REPLACEMENT .
  5. Install the door trim panel. Refer to TRIM PANEL REPLACEMENT - REAR DOOR (CARGO DOORS)  or TRIM PANEL REPLACEMENT - REAR DOOR (E54)  .
    Fig 2: Installing Door Handle Control Rod
    G01567357Courtesy of GENERAL MOTORS CORP.
scientia non olet · About LEMON Manuals