LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2002 >> Astro Van Passenger, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 825 (Body Rear End) >> Repair Instructions >> Door Rattle Adjustment - Rear

Door Rattle Adjustment - Rear

WARNING: This page is about a different car, the 2003 GMC Safari and 2003 Chevrolet Astro. However, it is still accessible from the selected car via links, so may be relevant.
  1. Check the spring-retained bumper on the lower edge of the door for tension. Replace the bumper assembly, if needed.
  2. Loosen the bolts that retain the edge guard plate on the rear door frame.
  3. Slide the plate forward.
    NOTE: Refer to FASTENER NOTICE in Cautions and Notices.
  4. Tighten the bolts that retain the edge guard plate on the rear door frame.

    Tighten 

    Tighten the bolts that retain the edge guard plate on the rear door frame to 5 N.m (45 lb in).

    Fig 1: Door Rattle Adjustment - Rear
    G01567330Courtesy of GENERAL MOTORS CORP.
scientia non olet · About LEMON Manuals