LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2002 >> Astro Van Passenger, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 820 (Bumper System) >> Repair Instructions >> Bumper Replacement - Rear >> Installation Procedure

Installation Procedure

WARNING: This page is about a different car, the 2003 GMC Safari and 2003 Chevrolet Astro. However, it is still accessible from the selected car via links, so may be relevant.
  1. Install the bracket to the bumper.
    NOTE: Refer to Fastener Notice in Cautions and Notices.
  2. Install the bracket to bumper bolts and nuts.

    Tighten 

    Tighten the bolts and nuts to 35 N.m (26 lb ft).

  3. Install the brace to the bumper.
  4. Install the brace to the bumper nuts.

    Tighten 

    Tighten the nuts to 35 N.m (26 lb ft).

  5. Install the bumper to the vehicle.
  6. Install the bracket to the frame bolts and nuts.

    Tighten 

    Tighten the bolts and nuts to 55 N.m (41 lb ft).

  7. Install the brace to the frame bolts.

    Tighten 

    Tighten the bolts to 35 N.m (26 lb ft).

  8. Remove the safety stands and lower the vehicle.
    Fig 1: Installing Rear Bumper
    G01566814Courtesy of GENERAL MOTORS CORP.
scientia non olet · About LEMON Manuals