LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2002 >> Astro Van Passenger, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 807 (Transfer Case - NVG 136-NP4) >> Repair Instructions >> Transfer Case Speed Sensor Replacement (Front) >> Installation Procedure

Installation Procedure

WARNING: This page is about a different car, the 2003 GMC Safari and 2003 Chevrolet Astro. However, it is still accessible from the selected car via links, so may be relevant.
NOTE: Refer to FASTENER NOTICE in Cautions and Notices.
  1. Install the transfer case front speed sensor.
    Fig 1: Transfer Case Front Speed Sensor
    G01643239Courtesy of GENERAL MOTORS CORP.

    Tighten 

    Tighten the transfer case front speed sensor to 15 N.m (11 lb ft).

  2. Install the transfer case front speed sensor electrical connector.
    Fig 2: Transfer Case Front Speed Sensor Electrical Connector
    G01643240Courtesy of GENERAL MOTORS CORP.
  3. Lower the vehicle. Refer to LIFTING AND JACKING THE VEHICLE in General Information.
scientia non olet · About LEMON Manuals