LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2002 >> Astro Van Passenger, AWD >> Repair and Diagnosis (Single Page) >> Body & Frame >> Exterior Body Panels >> Body Rear End >> Repair Instructions >> Lock Replacement - Rear Door (E54) >> Installation Procedure

Installation Procedure

  1. Install the clips to the lock.
  2. Install the lock to the door.
    3. NOTE: Refer to FASTENER NOTICE in GM Vehicles Cautions & Notices.
  3. Install the screws that retain the lock to the door. Tighten:  Tighten the screws that retain the lock to the door to 11 N.m (97 lb in).
  4. Install the control rods through the clips to the lock assembly.
  5. Install the water deflector. Refer to Water Deflector Replacement  .
  6. Install the trim panel. Refer to TRIM PANEL REPLACEMENT - REAR DOOR (CARGO DOORS)  or TRIM PANEL REPLACEMENT - REAR DOOR (E54)  .
    7. Fig 1: Removing & Installing Rear Door (E54) Lock Assembly
    G02507160Courtesy of GENERAL MOTORS CORP.
scientia non olet · About LEMON Manuals