LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2001 >> Venture Base, Van Passenger >> Repair and Diagnosis >> External Pages >> Different car >> Section 984 (Power Sun Roof) >> Repair Instructions >> Sunroof Actuator Replacement >> Removal Procedure

Removal Procedure

WARNING: This page is about a different car, the 2002 Pontiac Grand Prix. However, it is still accessible from the selected car via links, so may be relevant.

Important:  The sunroof actuator drive shaft turns in both directions and contains no limit switches. The sunroof actuator may be replaced with the glass panel in any position.

  1. Remove the headliner. Refer to HEADLINER REPLACEMENT in Interior Trim.
  2. Remove the tie strap from the wiring harness.
  3. Remove the screws from the sunroof actuator (1).
  4. Disconnect the electrical connector from the wiring harness.
  5. Pull straight down to disengage the drive gear.
  6. Remove the sunroof actuator from the sunroof module.
    Fig 1: Sunroof Actuator
    G01617241Courtesy of GENERAL MOTORS CORP.

scientia non olet · About LEMON Manuals