LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2001 >> Venture Base, Van Passenger >> Repair and Diagnosis >> External Pages >> Different car >> Section 984 (Power Sun Roof) >> Repair Instructions >> Sunroof Actuator Replacement >> Installation Procedure

Installation Procedure

WARNING: This page is about a different car, the 2002 Pontiac Grand Prix. However, it is still accessible from the selected car via links, so may be relevant.
  1. Position the sunroof actuator to the sunroof module.
  2. Connect the electrical connector to the wiring harness.
  3. Push the sunroof actuator straight in to engage its drive gear into the Position Encoding System Module.
    NOTE: Refer to FASTENER NOTICE in Cautions and Notices.
  4. Install the sunroof actuator screws (1) to the sunroof actuator.

    Tighten 

    Tighten the sunroof actuator screws to 3 N.m (27 lb in).

  5. Install the tie strap to the wiring harness (2).
    Fig 1: Sunroof Actuator
    G01617242Courtesy of GENERAL MOTORS CORP.
  6. Inspect the operation of the sunroof module.
  7. Install the headliner. Refer to HEADLINER REPLACEMENT in Interior Trim.
scientia non olet · About LEMON Manuals