LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2001 >> Venture Base, Van Passenger >> Repair and Diagnosis >> External Pages >> Different car >> Section 909 (Heating, Ventilation & Air Conditioning) >> Repair Instructions >> Blower Motor Replacement - Auxiliary (with E59) >> Removal Procedure

Removal Procedure

WARNING: This page is about a different car, the 2002 Pontiac Montana, 2002 Oldsmobile Silhouette, and 2002 Chevrolet Venture. However, it is still accessible from the selected car via links, so may be relevant.
  1. Remove the left lower quarter trim panel. Refer to TRIM PANEL REPLACEMENT - REAR QUARTER LOWER .
  2. Disconnect the auxiliary blower motor electrical connector.
  3. Disconnect the auxiliary blower motor resistor electrical connector.
    4. Fig 1: Auxiliary Blower Motor Housing
    G01828081Courtesy of GENERAL MOTORS CORP.
  4. Remove the lower auxiliary air distribution duct bolts and retainers.
  5. Remove the lower auxiliary air distribution duct.

    Important:  The auxiliary blower motor must be removed with the blower motor housing.

  6. Remove the auxiliary blower motor housing screws.
  7. Lift the auxiliary blower motor housing and remove from the HVAC module assembly.
    8. Fig 2: Auxiliary Blower Motor
    G01828082Courtesy of GENERAL MOTORS CORP.
  8. Remove the auxiliary blower motor mounting screws.
  9. Remove the auxiliary blower motor from the blower motor housing.
scientia non olet · About LEMON Manuals