LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2001 >> Venture Base, Van Passenger >> Repair and Diagnosis >> External Pages >> Different car >> Section 888 (Engine Mechanical - 3.8L) >> Repair Instructions >> Off-Vehicle Repair Instructions >> Exhaust Manifold Removal - Right

Exhaust Manifold Removal - Right

WARNING: This page is about a different car, the 2003 Buick Regal. However, it is still accessible from the selected car via links, so may be relevant.
  1. Remove the heated oxygen sensor lead.
    Fig 1: Removing Heated Oxygen Sensor Lead
    G01969334Courtesy of GENERAL MOTORS CORP.
  2. Remove the fuel injector sight shield mounting bracket nuts.
  3. Remove the fuel injector sight shield mounting bracket.
    Fig 2: Removing Fuel Injector Sight Shield Mounting Bracket & Nuts
    G01969335Courtesy of GENERAL MOTORS CORP.
  4. Remove the right engine lift hook nut and bolt.
  5. Remove the right engine lift hook bracket.
  6. Remove the right side spark plugs.
    Fig 3: Removing Right Engine Lift Hook Bracket, Nut & Bolt
    G01969336Courtesy of GENERAL MOTORS CORP.
  7. Remove the exhaust manifold studs.
  8. Remove the exhaust manifold.
  9. Remove the exhaust manifold gasket.
    Fig 4: Removing Right Exhaust Manifold & Gasket
    G01969337Courtesy of GENERAL MOTORS CORP.
  10. Remove the exhaust manifold studs.
    Fig 5: Removing Right Exhaust Manifold Studs
    G01969338Courtesy of GENERAL MOTORS CORP.
scientia non olet · About LEMON Manuals