LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2001 >> Venture Base, Van Passenger >> Repair and Diagnosis >> External Pages >> Different car >> Section 709 (Engine Mechanical - 3.8L) >> Repair Instructions >> Off-Vehicle Repair Instructions >> Water Pump Installation

Water Pump Installation

WARNING: This page is about a different car, the 2003 Pontiac Grand Prix. However, it is still accessible from the selected car via links, so may be relevant.
  1. Install the water pump gasket.
  2. Install the water pump.
    NOTE: Refer to FASTENER NOTICE in Cautions and Notices.
  3. Install the water pump bolts.

    Tighten 

    • Tighten the small water pump bolts to 22 N.m (16 lb ft).
    • Tighten the large water pump bolts to 34 N.m (25 lb ft).
    Fig 1: Installing Water Pump And Gasket
    G02083949Courtesy of GENERAL MOTORS CORP.
  4. Install the water pump pulley.
  5. Install the water pump pulley bolts.

    Tighten 

    Tighten the water pump pulley bolts to 13 N.m (116 lb in).

    Fig 2: Installing Water Pump Pulley
    G02083950Courtesy of GENERAL MOTORS CORP.
scientia non olet · About LEMON Manuals