LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2001 >> Venture Base, Van Passenger >> Repair and Diagnosis >> External Pages >> Different car >> Section 708 (Engine Mechanical - 3.1L) >> Repair Instructions >> Off-Vehicle Repair Instructions >> Oil Pump Installation

Oil Pump Installation

WARNING: This page is about a different car, the 2003 Pontiac Grand Prix. However, it is still accessible from the selected car via links, so may be relevant.
  1. Install the crankshaft oil deflector.
    NOTE: Refer to FASTENER NOTICE in Cautions and Notices.
  2. Install the crankshaft oil deflector nuts.

    Tighten 

    Tighten the crankshaft oil deflector nuts to 25 N.m (18 lb ft).

    Fig 1: Installing Crankshaft Oil Deflector
    G02081715Courtesy of GENERAL MOTORS CORP.

    Important:  Do not reuse the oil pump driveshaft retainer. During assembly, install a NEW oil pump driveshaft retainer.

  3. Install the oil pump.
  4. Position the oil pump onto the pins.
  5. Install the oil pump bolt attaching the oil pump to the rear crankshaft bearing cap.

    Tighten 

    Tighten the oil pump bolt to 41 N.m (30 lb ft).

    Fig 2: Installing Oil Pump
    G02081716Courtesy of GENERAL MOTORS CORP.
scientia non olet · About LEMON Manuals