LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2001 >> Venture Base, Van Passenger >> Repair and Diagnosis >> External Pages >> Different car >> Section 382 (Engine Mechanical - 2.2L) >> Removal And Installation >> Unit Repair Disassembly >> Water Pump (Unit Repair) Removal >> Removal

Water Pump (Unit Repair) Removal: Removal

WARNING: This page is about a different car, the 2003 Saturn Vue. However, it is still accessible from the selected car via links, so may be relevant.
  1. Remove engine coolant temperature sensor.
    Fig 1: Removing Engine Coolant Temperature Sensor
    G01039528Courtesy of GENERAL MOTORS CORP.
  2. Remove thermostat and water feed pipe retaining bolts.

    IMPORTANT:  Twist the water feed pipe while pulling to remove it from the water pump.

  3. Remove thermostat housing and water feed pipe from water pump.
    Fig 2: Removing Thermostat And Water Feed Pipe
    G01039529Courtesy of GENERAL MOTORS CORP.

    IMPORTANT:  Be sure to remove the bolt that goes through the front of the engine block.

  4. Remove water pump retaining bolts.
  5. Remove water pump assembly.
    Fig 3: Removing Water Pump Assembly
    G01039530Courtesy of GENERAL MOTORS CORP.
scientia non olet · About LEMON Manuals