Battery Cooling Box: Removal
WARNING: This page is about a different car, the 2002 Saturn Vue. However, it is still accessible from the selected car via links, so may be relevant.
CAUTION:
DO NOT tip battery over 45 degree angle or acid could spill.
NOTE:
Record all pre-set radio stations prior to disconnecting battery and reprogram pre-set stations after repair.
- Remove battery cover. Disconnect negative battery cable. Disconnect positive battery cable. Loosen battery hold-down screw and remove battery. See Fig 1 . Remove underhood fuse box cover. Remove positive battery cable and EPS wire from positive battery terminal at underhood fuse box. Open all retainer clips and remove all cables, lines and harnesses from battery cooling box.
- Loosen underhood fuse box connector retaining screws. Unfasten underhood fuse box from its housing and disconnect forward lamp harness. See Fig 2 . Remove battery cooling box screws. Remove battery cooling box side support screw. Pull inlet duct away from battery cooling box. Rotate underhood fuse box out of way and remove battery cooling box.
CAUTION:
Protect disconnected harness from contamination during service.