LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2001 >> Venture Base, Van Passenger >> Repair and Diagnosis >> External Pages >> Different car >> Section 159 (Engine Controls - Removal & Installation) >> Relays & Solenoids >> Low Pressure Lock-Off Solenoid >> Removal

Low Pressure Lock-Off Solenoid: Removal

WARNING: This page is about a different car, the 2003 Pontiac Sunfire and 2003 Chevrolet Cavalier. However, it is still accessible from the selected car via links, so may be relevant.
  1. Low Pressure Lock-Off (LPL) solenoid is mounted in the Intermediate pressure line. See Figure. Release CNG fuel system pressure. See FUEL SYSTEM PRESSURE RELEASE (CNG)  under FUEL SYSTEMS (CNG).
  2. Remove the battery, air cleaner outlet duct and the air cleaner assembly.
  3. Disconnect the fuel line from the LPL fuel inlet elbow. See Figure.
  4. Remove the fuel rail feed hose hold-down nut and retainer. See Fig 1.
  5. Remove the fuel feed hose from the LPR using a twisting motion.
  6. Disconnect the LPL harness connector.
  7. Remove the LPR/LPL mounting bracket nuts. See Fig 1.
  8. Remove the LPR/LPL assembly from the vehicle.
  9. Remove the LPR and LPL mounting bolts.
  10. Remove the LPR/LPL assembly from the mounting bracket.
  11. While holding the union with a wrench, rotate the LPL to separate the components. See Fig 2.
Fig 1: Locating Low Pressure Regulator & Low Pressure Lock-Off Solenoid
G00196164Courtesy of GENERAL MOTORS CORP.
Fig 2: Separating LPL & LPR
G00217321Courtesy of GENERAL MOTORS CORP.
scientia non olet · About LEMON Manuals