LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2001 >> Cavalier LS, 2.2 4 >> Repair and Diagnosis >> External Pages >> Different car >> Section 353 (Sunroof System) >> Repair Instructions >> Sunroof Drive Cable Replacement >> Removal Procedure

Removal Procedure

WARNING: This page is about a different car, the 2003 Pontiac Sunfire and 2003 Chevrolet Cavalier. However, it is still accessible from the selected car via links, so may be relevant.
  1. Remove the sunroof window. Refer to SUNROOF WINDOW REPLACEMENT  .
  2. Use J 38043  in the sunroof motor slot and manually lower the sunroof guides to the closed position.
  3. Disconnect the sunroof motor/actuator.
    Fig 1: Removing Cable Retainers
    G01559853Courtesy of GENERAL MOTORS CORP.
  4. From above the vehicle, remove the left and the right cable retainer fasteners from the sunroof.
  5. Remove the retainers.
  6. Lift the sunroof drive cable end out of the guide assembly.
  7. Hold the sunroof drive cable guide tubes in position.
  8. Pull the sunroof drive cables out of the guide tubes.
    Fig 2: Removing Sunroof Drive Cables
    G01559854Courtesy of GENERAL MOTORS CORP.
scientia non olet · About LEMON Manuals