LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2001 >> Cavalier LS, 2.2 4 >> Repair and Diagnosis >> External Pages >> Different car >> Section 345 (Instrument Panel, Gages, And Console) >> Repair Instructions >> Trim Pad Replacement - Instrument Panel (I/P) (Chevrolet) >> Installation Procedure

Installation Procedure

WARNING: This page is about a different car, the 2003 Pontiac Sunfire and 2003 Chevrolet Cavalier. However, it is still accessible from the selected car via links, so may be relevant.
  1. Install the I/P trim pad (2) to the I/P carrier.
    NOTE: Refer to FASTENER NOTICE in Cautions and Notices.
  2. Install the I/P trim pad screws (1).

    Tighten 

    Tighten the screws to 2.3 N.m (20 lb in).

  3. Close the I/P compartment door.
  4. Align the outer trim covers locating tabs into the I/P carrier.

    Press the cover into the I/P carrier until fully engaged.

  5. Install the defroster grille to the I/P trim pad.
  6. Install the defroster grille screw.

    Tighten 

    Tighten the screw to 2.3 N.m (20 lb in).

  7. Enable the SIR system. Refer to DISABLING & ACTIVATING AIR BAG SYSTEM and DISABLING & ACTIVATING AIR BAG SYSTEM in SIR.
    Fig 1: Installing I/P Trim Pad To I/P carrier (Chevrolet)
    G01559260Courtesy of GENERAL MOTORS CORP.
scientia non olet · About LEMON Manuals