LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2001 >> Cavalier LS, 2.2 4 >> Repair and Diagnosis >> External Pages >> Different car >> Section 243 (Manual Transmission - GETRAG 5 Speed) >> Repair Instructions >> Vehicle Speed Sensor (VSS) Replacement >> Installation Procedure

Installation Procedure

WARNING: This page is about a different car, the 2004 Pontiac Sunfire and 2004 Chevrolet Cavalier. However, it is still accessible from the selected car via links, so may be relevant.
  1. Lubricate a new O-ring with DEXRON III transmission fluid.
  2. Install the new O-ring.
  3. Install the VSS retainer.
    Fig 1: Identifying VSS Retainer
    GM12407Courtesy of GENERAL MOTORS CORP.
  4. Install the vehicle speed sensor (VSS) assembly.
    NOTE: Refer to FASTENER NOTICE in Cautions and Notices.
  5. Install the VSS retainer bolt.

    Tighten:  Tighten the bolt to 9 N.m (80 lb in).

  6. Connect the VSS connector to the VSS.
    Fig 2: Locating Vehicle Speed Sensor (VSS)
    GM623138Courtesy of GENERAL MOTORS CORP.
  7. Lower the vehicle.
scientia non olet · About LEMON Manuals