LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2001 >> Cavalier LS, 2.2 4 >> Repair and Diagnosis >> External Pages >> Different car >> Section 242 (Heating, Ventilation And Air Conditioning - Gas) >> Diagnostic Information and Procedures >> Air Conditioning (A/C) Diagnostics - Pressure Zone C

Air Conditioning (A/C) Diagnostics - Pressure Zone C

WARNING: This page is about a different car, the 2004 Pontiac Sunfire and 2004 Chevrolet Cavalier. However, it is still accessible from the selected car via links, so may be relevant.
Air Conditioning (A/C) Diagnostics - Pressure Zone C

Step Action Yes No
DEFINITION: The low and the high side pressures are both higher than normal.
  • Restricted Condenser Air Flow
  • Cooling Fan Malfunction
  • Expansion Device Malfunction
1 Were you sent here from the A/C System Performance Test? Go to Step 2  Go to Air Conditioning (A/C) System Performance Test 
2
  1. Start the engine.
  2. Turn on the A/C.
  3. Inspect for proper cooling fan operation. Refer to Cooling System Description and Operation in Engine Cooling.
Are the cooling fans ON and operating properly?		 Go to Step 3  Go to Step 5 
3 Visually inspect for the following:
  • Restricted air flow
  • Damaged condenser cooling fins
  • Missing or misaligned air baffles.

Do any of these conditions exist?		 Go to Step 4  Go to Step 6 
4 Repair the air flow restriction.
Is the action complete?		 Go to Step 9  -
5 Repair the cooling fan operation fault. Refer to Cooling Fan Inoperative in Engine Cooling.
Is the action complete?		 Go to Step 9  -
6
CAUTION: Refer toMoving Parts and Hot Surfaces Caution in Cautions and Notices.
Feel the liquid line on both sides of the expansion device.Is the temperature the same before and after the expansion device?		 Go to Step 7  Go to Step 8 
7 Replace the damaged or faulty orifice tube. Refer to Expansion (Orifice) Tube Replacement .
Is the action complete?		 Go to Step 9  -
8 Air is in the refrigerant system, or the system is overcharged. Refer to the view screen on the J 43600  for foreign gas content in the refrigerant. See Special Tools and Equipment .
Recover and recharge the A/C system. Refer to Refrigerant Recovery and Recharging .
Is the action complete?		 Go to Step 9  -
9
  1. Record the low and high side pressures and the instrument panel outlet air temperature after you have performed the repairs.
  2. Compare the pressures and the instrument panel outlet air temperature to those listed in the A/C Performance Chart. Refer to Air Conditioning (A/C) System Performance Test .
Are the readings within the specified ranges?		 Go to Step 10  Go to Air Conditioning (A/C) System Performance Test 
10 Operate the system in order to verify the repair.
Did you find and correct the condition?		 System OK Go to Symptoms - HVAC Systems - Manual in HVAC Systems - Manual
scientia non olet · About LEMON Manuals