LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2001 >> Cavalier LS, 2.2 4 >> Repair and Diagnosis >> External Pages >> Different car >> Section 232 (Wiper System & Washer System) >> Repair Instructions >> Wiper Transmission Replacement >> Removal Procedure

Removal Procedure

WARNING: This page is about a different car, the 2004 Pontiac Sunfire and 2004 Chevrolet Cavalier. However, it is still accessible from the selected car via links, so may be relevant.
  1. Remove the air inlet grille panel. Refer to Air Inlet Grille Panel Replacement in Body Front End.
  2. Disconnect the wiper motor electrical connector.
    Fig 1: Disconnecting Wiper Motor Electrical Connector
    GM1200401Courtesy of GENERAL MOTORS CORP.
  3. Remove the wiper drive system module screws.
  4. Remove the wiper drive system module from the vehicle.
  5. Using the J 39232  , disconnect the wiper transmission from the wiper motor crank arm. See Special Tools and Equipment .
    6. Fig 2: Disconnecting Wiper Transmission From Wiper Motor Crank Arm
    GM306506Courtesy of GENERAL MOTORS CORP.
  6. Remove the wiper transmission caps.
  7. Remove the wiper transmission screws.
  8. Remove the wiper transmission from the wiper drive system module tube frame.
    9. Fig 3: Removing Wiper Transmission Screws
    GM347712Courtesy of GENERAL MOTORS CORP.
scientia non olet · About LEMON Manuals