LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2001 >> Cavalier LS, 2.2 4 >> Repair and Diagnosis >> External Pages >> Different car >> Section 232 (Wiper System & Washer System) >> Repair Instructions >> Wiper Motor Replacement >> Removal Procedure

Removal Procedure

WARNING: This page is about a different car, the 2004 Pontiac Sunfire and 2004 Chevrolet Cavalier. However, it is still accessible from the selected car via links, so may be relevant.
  1. Remove the air inlet grille panel. Refer to Air Inlet Grille Panel Replacement in Body Front End.
  2. Disconnect the wiper motor electrical connector.
    Fig 1: Disconnecting Wiper Motor Electrical Connector
    GM347709Courtesy of GENERAL MOTORS CORP.
  3. Remove the screws from the wiper drive system module.
  4. Remove the wiper drive system module from the vehicle.
  5. Using J 39232  , disconnect the transmission from the wiper motor crank arm. See Special Tools and Equipment .
    6. Fig 2: Disconnecting Wiper Transmission From Wiper Motor Crank Arm
    GM306506Courtesy of GENERAL MOTORS CORP.
  6. Remove the wiper motor screws.
  7. Remove the wiper motor from the wiper drive system module.
    Fig 3: Removing Wiper Motor Screws
    GM347710Courtesy of GENERAL MOTORS CORP.
scientia non olet · About LEMON Manuals