LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2001 >> Cavalier LS, 2.2 4 >> Repair and Diagnosis >> External Pages >> Different car >> Section 232 (Wiper System & Washer System) >> Repair Instructions >> Washer Solvent Container Replacement >> Removal Procedure

Removal Procedure

WARNING: This page is about a different car, the 2004 Pontiac Sunfire and 2004 Chevrolet Cavalier. However, it is still accessible from the selected car via links, so may be relevant.
  1. Open the hood.
  2. Drain the washer solvent from the washer solvent container.
  3. Remove the washer solvent container cap.
  4. Remove the left front fender liner. Refer to Front Fender Liner Replacement in Body Front End.
  5. Disconnect the anti-lock brake electrical harness from the washer solvent container.
    6. Fig 1: Disconnecting Anti-Lock Brake Electrical Harness
    GM827811Courtesy of GENERAL MOTORS CORP.
  6. Disconnect the washer pump electrical connector.
    Fig 2: Disconnecting Washer Pump Electrical Connector
    GM452363Courtesy of GENERAL MOTORS CORP.
  7. Disconnect the washer pump hose.
  8. Remove the push-in retainer from the air induction tube.
    Fig 3: Removing Air Induction Tube Push-In Retainer
    GM639597Courtesy of GENERAL MOTORS CORP.
  9. Remove the washer solvent container screws.
  10. Remove the washer solvent container from the vehicle.
  11. Remove the air induction tube screw.
  12. Remove the air induction tube from the washer solvent container.
    Fig 4: Removing Air Induction Tube Screw
    GM639598Courtesy of GENERAL MOTORS CORP.
scientia non olet · About LEMON Manuals