Wipers Always On
WARNING: This page is about a different car, the 2004 Pontiac Sunfire and 2004 Chevrolet Cavalier. However, it is still accessible from the selected car via links, so may be relevant.
Wipers Always On
| Step | Action | Yes | No |
|---|---|---|---|
| Schematic Reference: Wiper/Washer System Schematics Connector End View Reference: Wiper/Washer System Connector End Views |
|||
| 1 | Did you review the Wiper/Washer System Description and Operation and perform the necessary inspections? | Go to Step 2 | Go to Symptoms - Wiper/Washer Systems |
| 2 |
|
Go to Testing for Intermittent Conditions and Poor Connections in Wiring Systems | Go to Step 3 |
| 3 | Are the windshield washers on along with the wipers? | Go to Washers Always On | Go to Step 4 |
| 4 |
|
Go to Step 6 | Go to Step 5 |
| 5 | Connect a test lamp from the signal 2 circuit of the windshield wiper switch to a good ground. Does the test lamp illuminate? |
Go to Step 7 | Go to Step 9 |
| 6 | Test the windshield wiper switch signal 1 circuit for a short to voltage. Refer to Circuit Testing
and Wiring Repairs
in Wiring Systems. Did you find and correct the condition? |
Go to Step 12 | Go to Step 8 |
| 7 | Test the windshield wiper switch signal 2 circuit for a short to voltage. Refer to Circuit Testing
and Wiring Repairs
in Wiring Systems. Did you find and correct the condition? |
Go to Step 12 | Go to Step 8 |
| 8 | Inspect for poor connections at the harness connector of the windshield wiper/washer switch. Refer to Testing for Intermittent Conditions and Poor Connections
and Connector Repairs
in Wiring Systems. Did you find and correct the condition? |
Go to Step 12 | Go to Step 10 |
| 9 | Inspect for poor connections at the harness connector of the windshield wiper motor module. Refer to Testing for Intermittent Conditions and Poor Connections
and Connector Repairs
in Wiring Systems. Did you find and correct the condition? |
Go to Step 12 | Go to Step 11 |
| 10 | Replace the windshield wiper/washer switch. Refer to Wipers/Washer Switch Replacement in Steering Wheel and Column. Did you complete the replacement? |
Go to Step 12 | - |
| 11 | Replace the windshield wiper motor module. Refer to Wiper Motor Cover Replacement . Did you complete the replacement? |
Go to Step 12 | - |
| 12 | Operate the system in order to verify the repair. Did you correct the condition? |
System OK | Go to Step 3 |