LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2001 >> Cavalier LS, 2.2 4 >> Repair and Diagnosis >> External Pages >> Different car >> Section 216 (Sunroof System) >> Repair Instructions >> Sunroof Wiring Harness Replacement >> Removal Procedure

Removal Procedure

WARNING: This page is about a different car, the 2004 Pontiac Sunfire and 2004 Chevrolet Cavalier. However, it is still accessible from the selected car via links, so may be relevant.
  1. Remove the headlining trim finish panel. Refer to Headliner Replacement in Interior Trim.
  2. Disconnect the electrical connector from the following components:
    1. The sunroof control switch (3)
    2. The sunroof express module (2)
    3. The sunroof motor (4)
    4. The body harness (1).
      Fig 1: Disconnecting Sunroof Control Switch
      GM750852Courtesy of GENERAL MOTORS CORP.
    IMPORTANT:
    • Note the location of the wiring harness.
    • Note the location of the tie-straps that secure the harness to the drive cables and to the sunroof module.
  3. Remove the wiring harness from the sunroof.
scientia non olet · About LEMON Manuals