LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2001 >> Cavalier LS, 2.2 4 >> Repair and Diagnosis >> External Pages >> Different car >> Section 216 (Sunroof System) >> Repair Instructions >> Sunroof Drive Cable Replacement >> Removal Procedure

Removal Procedure

WARNING: This page is about a different car, the 2004 Pontiac Sunfire and 2004 Chevrolet Cavalier. However, it is still accessible from the selected car via links, so may be relevant.
  1. Remove the sunroof window. Refer to Sunroof Window Replacement .
  2. Use J 38043  in the sunroof motor slot and manually lower the sunroof guides to the closed position. See Special Tools and Equipment .
  3. Disconnect the sunroof motor/actuator.
  4. From above the vehicle, remove the left and the right cable retainer fasteners from the sunroof.
  5. Remove the retainers.
    Fig 1: Removing Cable Retainer Fasteners
    GM294346Courtesy of GENERAL MOTORS CORP.
  6. Lift the sunroof drive cable end out of the guide assembly.
  7. Hold the sunroof drive cable guide tubes in position.
  8. Pull the sunroof drive cables out of the guide tubes.
    Fig 2: Removing Sunroof Drive Cable
    GM294349Courtesy of GENERAL MOTORS CORP.
scientia non olet · About LEMON Manuals