Installation Procedure

WARNING: This page is about a different car, the 2004 Pontiac Sunfire and 2004 Chevrolet Cavalier. However, it is still accessible from the selected car via links, so may be relevant.

Install the sunroof drain hose into the rear compartment through the access hole.
Press the sunroof drain hose into the retaining clip along the rear pillar.

Fig 1: Aligning Sunroof Drain Hose
Courtesy of GENERAL MOTORS CORP.
Connect the sunroof drain hose (1) to the sunroof rear drain port.

Fig 2: Connecting Sunroof Rear Drain Port
Courtesy of GENERAL MOTORS CORP.
Press the sunroof drain hose into the retaining clip along the quarter panel.

Fig 3: Identifying Sun Roof Drain Hose Retaining Clip
Courtesy of GENERAL MOTORS CORP.
Connect the sunroof drain hose to the drain hose outlet.

Fig 4: Connecting Sunroof Drain Hose To The Drain Hose Outlet
Courtesy of GENERAL MOTORS CORP.
Press the sunroof drain hose (1) outlet into the quarter panel drain hole.

Fig 5: Pressing The Sunroof Drain Hose Outlet Into The Quarter Panel Drain Hole
Courtesy of GENERAL MOTORS CORP.
Check the sunroof drain hose for play. Secure the drain hose to the quarter panel or roof with 3M™ double sided tape P/N 06377 or equivalent, to prevent rattles.
Place the rear compartment trim back to the original position.
Install the headliner. Refer to Headliner Replacement in Interior Trim.